全自動攪拌車攪拌器的動力由二級底盤的動力提取器通過傳動軸傳遞給液壓泵。液壓泵產生的液壓能量通過油管傳遞給液壓馬達。液壓馬達將液壓能量轉化為動能，通過減速機輸送到攪拌槽。使用一段時間後，過多過少的攪拌桶就會出現攪拌不轉的情況，一般有三種情況:
The power of the mixer of the fully automatic mixing truck is transmitted to the hydraulic pump through the transmission shaft by the power extractor of the secondary chassis. The hydraulic energy generated by the hydraulic pump is transmitted to the hydraulic motor through the oil pipe. The hydraulic motor converts hydraulic energy into kinetic energy and transmits it to the mixing tank through a reducer. After using for a period of time, too many or too few mixing drums will cause mixing to fail, generally in three situations:
1.混凝土在運輸過程中被卡住;
1. The concrete is stuck during transportation;
2.液壓係統或發動機故障;
2. Hydraulic system or engine failure;
3.馬達出故障了。
The motor is out of order.
解決方案:
Solution:
混凝土在運輸過程中被卡住;清理幹淨就沒有問題了;
The concrete is stuck during transportation; Clean it up and there's no problem;
液壓係統或發動機故障處理:
Troubleshooting of hydraulic system or engine faults:
(1)打開攪拌桶人孔蓋，鬆開馬達上高壓軟管的管接頭，旋轉攪拌桶使攪拌桶人孔斜向下，從攪拌桶人孔排出混凝土;
(1) Open the manhole cover of the mixing drum, loosen the pipe joint of the high-pressure hose on the motor, rotate the mixing drum to make the manhole of the mixing drum incline downward, and discharge concrete from the manhole of the mixing drum;
(2)麻煩卡車高壓軟管從救濟的電動機用高壓軟管連接到另一端的油泵救援車,後將用於緊急回水管有麻煩卡車機油口、回油管另一端用泵抽油口後救援車輛,使用救援車來控製麻煩卡車的旋轉圓柱,具體的排放。
(2) The high-pressure hose of the troublesome truck is connected from the relief motor to the oil pump rescue vehicle at the other end using a high-pressure hose, which will then be used to rescue the vehicle after the emergency water return pipe has an oil port of the troublesome truck, and the other end of the oil return pipe uses a pump suction port. The rescue vehicle is used to control the rotating cylinder of the troublesome truck, with specific emissions.
電機故障，處理相對簡單，可將電機從救援車上拆下安裝在故障車上，然後將各油管連接起來，啟動救援車時可將混凝土氣缸混出。
The handling of motor faults is relatively simple. The motor can be removed from the rescue vehicle and installed on the faulty vehicle, and then all oil pipes can be connected. When starting the rescue vehicle, concrete cylinders can be mixed out.
全自動攪拌車作為運輸車輛，應遵守交通部養護維修規定，實行“定期檢查、強製養護、視情維修”的養護製度。在這個大前提下，結合全自動攪拌車的實際情況，做好養護維修工作。在日常養護方麵，車輛應按照汽車發動機、底盤等部件的日常養護，還必須做好養護工作。更多相關內容就來kaiyun網站http://www.skar-bnat.com谘詢吧！
As a transportation vehicle, fully automatic mixer trucks should comply with the maintenance regulations of the Ministry of Communications, and implement a maintenance system of "regular inspection, mandatory maintenance, and maintenance as appropriate.". Under this premise, combined with the actual situation of fully automatic mixer trucks, maintenance and repair work should be done well. In terms of daily maintenance, vehicles should be maintained in accordance with the daily maintenance of automobiles engines, chassis, and other components, and maintenance work must also be done well. For more relevant content, please visit our website http://www.skar-bnat.com Consult!
