都知道混凝土攪拌車是運輸混凝土的專用車輛，但行業外的人不明白攪拌車的使用方麵內容，那麽kaiyun先看看混凝土攪拌車的主要使用特點，掌握以下幾點，想不正確使用都難。
We all know that concrete mixer is a special vehicle for transporting concrete, but people outside the industry don't understand the use of mixer. Let's first look at the main use characteristics of concrete mixer and master the following points. It's difficult to use it correctly.
1、攪拌車液壓傳動係統液壓油的壓力、油量、油質、油溫應達到規定要求，無滲漏現象
1. The pressure, quantity, quality and temperature of the hydraulic oil in the hydraulic transmission system of the mixer shall meet the specified requirements without leakage
2、攪拌運輸中，裝載混凝土量不能超過允許裝載質量。
2. During mixing and transportation, the amount of concrete loaded shall not exceed the allowable loading quality.
3、攪拌車在露天停放時，裝料前應先將攪拌筒反轉，使筒內的積水和雜物排出。裝料前，好先向筒內加水，使進料流暢，防止粘料。
3. When the mixer truck is parked in the open air, the mixing drum should be reversed before loading to drain the water and debris in the drum. Before loading, add water to the barrel to make the feeding smooth and prevent sticking.
4、攪拌車行駛中，接長的卸料槽必須翻轉後固定在卸槽上，再轉至與車身垂直部位，用銷軸與機架固定，防止由於不固定而引起擺動，打傷行人或影響車輛運行。
4. During the driving of the mixer truck, the extended discharge chute must be turned over and fixed on the discharge chute, and then turned to the vertical position with the vehicle body, and fixed with the frame with a pin shaft, so as to prevent swing caused by unfixed, injury to pedestrians or affect the operation of the vehicle.
5、攪拌車通過橋、洞、庫等設施時，應注意通過高度及寬度，以免發生碰撞事故。特別需要注意的是現在四軸罐車的長度很長，在通過橋洞高度接近極限時，長長的車身是下圓弧路麵的一道弦，能通過的高度會降低。
5. When the mixer truck passes through bridges, holes, warehouses and other facilities, attention should be paid to the passing height and width to avoid collision accidents. It should be noted that the length of the four axle tank car is very long now. When the height of the bridge opening is close to the limit, the long body is a chord of the lower arc road surface, and the height that can be passed will be reduced.
6、攪拌裝置連續運轉時間不超過8h。
6. The continuous operation time of the mixing device shall not exceed 8h.
7、攪拌車運送混凝土的時間不得超過攪拌車規定的時間，以免影響混凝土質量。
7. The time of transporting concrete by the mixer truck shall not exceed the time specified by the mixer truck, so as not to affect the quality of concrete.
8、運送混凝土途中，攪拌筒不得停轉，以防混凝土產生初凝及離析現象。
8. During the transportation of concrete, the mixing drum shall not be stopped to prevent the initial setting and segregation of concrete.
9、攪拌筒由正轉變為反轉時，必須先將操縱手柄放置中間位置，待攪拌筒停轉後，再將操縱手柄放置反轉位置。
9. When the mixing drum changes from positive to reverse, the control handle must be placed in the middle position first, and then placed in the reverse position after the mixing drum stops rotating.
10、混凝土攪拌車的水箱的水量要盡量保持裝滿，以防急用。冬季停車時，要將水箱和供水係統的水放淨。
10. The water volume of the water tank of the concrete mixer shall be kept as full as possible to prevent emergency use. When parking in winter, drain the water from the water tank and water supply system.
此外混凝土運輸中通過攪拌筒的緩慢旋轉，可有效地防止防止混凝土初凝及離析，因而能保證混凝土的輸送質量，以後再碰到關注攪拌車的相關問題就能快速解決了。
In addition, the slow rotation of the mixing drum during concrete transportation can effectively prevent the initial setting and segregation of concrete, so as to ensure the delivery quality of concrete. In the future, the related problems of paying attention to the mixing truck can be quickly solved.
以上就是問題解答的相關內容了，希望能夠幫助到大家，如對這一問題還存在任何疑問，都歡迎關注kaiyun網站http://www.skar-bnat.com並谘詢kaiyun的工作人員，將竭誠為您服務。
The above is the relevant content of the question answer. I hope it can help you. If you still have any questions about this problem, you are welcome to follow our website http://www.skar-bnat.com And consult our staff, will serve you wholeheartedly.
