您好,歡迎光臨萊州kaiyun機械有限公司官方網站!

服務熱線

400-879-1999

你所在位置: 首頁 >> kaiyun > 常見問題 >
常見問題

為保證全自動混凝土攪拌車的驅動裝置完好可靠應如何維護

來源:http://www.skar-bnat.com/ 時間:2020-11-24

  驅動裝置的作用是驅動混凝土貯罐轉動,它由取力器、萬向軸、液壓泵、液壓馬達、操縱閥、液壓油箱及冷卻裝置組成。如果這部分因故障停止工作,混凝土貯罐將不能轉動,這會導致車內混凝土報廢,嚴重的甚至使整罐混凝土凝結在罐內,造成混凝土攪拌運輸車報廢。因此,驅動裝置是否可靠是使用中需要高度重視的問題。為保證驅動裝置完好可靠,應做好以下維護工作:
The driving device is used to drive the concrete storage tank to rotate. It is composed of power take-off, universal axis, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device. If this part stops working due to fault, the concrete tank will not be able to rotate, which will lead to the scrapping of the concrete in the vehicle, and even make the whole tank concrete coagulate in the tank, resulting in the scrapping of the concrete mixer truck. Therefore, whether the driving device is reliable or not is a problem that needs high attention in use. In order to ensure the integrity and reliability of the drive device, the following maintenance work should be done well:
1.萬向轉動部分是故障多發部位,應按時加注潤滑脂,並經常檢查磨損情況,及時修理更換。車隊應有備用的萬向軸總成,以保證一旦發生故障能在幾十分鍾內恢複工作。
The universal rotating part is a fault prone part, so grease should be added on time, and the wear condition should be checked frequently, and the repair and replacement should be carried out in time. The team should have spare cardan shaft assembly to ensure that it can resume work in dozens of minutes in case of failure.
2.保證液壓油清潔。混凝土攪拌運輸車工作環境惡劣,一定要防止汙水泥沙進入液壓係統。液壓油要按使用手冊要求定期更換。一旦檢查時發現液壓油中混入水或泥沙,就要立即停機清洗液壓係統、更換液壓油。
Keep the hydraulic oil clean. The working environment of concrete mixer truck is bad, so it is necessary to prevent dirty cement sand from entering the hydraulic system. The hydraulic oil should be replaced regularly according to the requirements of the manual. Once it is found that the hydraulic oil is mixed with water or sediment, it is necessary to stop the machine immediately to clean the hydraulic system and replace the hydraulic oil.
全自動混凝土攪拌車
3.保證液壓油冷卻裝置有效。要定時清理液壓油散熱器,避免散熱器被水泥堵塞,檢查散熱器電動風扇運轉是否正常,防止液壓油溫度超標。液壓部分隻要保證液壓油清潔,一般故障不多;但生產廠家不同,使用壽命則不一樣。
Ensure that the hydraulic oil cooling device is effective. The hydraulic oil radiator should be cleaned regularly to prevent the radiator from being blocked by cement, and check whether the electric fan of radiator operates normally to prevent the temperature of hydraulic oil exceeding the standard. As long as the hydraulic oil is clean, there are not many faults in the hydraulic part, but the service life varies with the manufacturer.
感謝您的閱讀,此文的文章來源:全自動混凝土攪拌車更多的內容和問題請點擊:http://www.skar-bnat.com/kaiyun會繼續努力的為您提供服務,感謝您的支持!
Thank you for reading. This article is from automatic concrete mixer. For more information and questions, please click: http://www.skar-bnat.com/ We will continue to work hard to provide services for you, thank you for your support!


上一篇:自上料混凝土攪拌車傳動油質量檢測方法有哪些?
下一篇:一輛攪拌車合格的技術標準必須滿足哪些?
tag:混凝土攪拌車,小型混凝土攪拌車,全自動混凝土攪拌車
當前位置: 首頁 - kaiyun > 常見問題 >

為保證全自動混凝土攪拌車的驅動裝置完好可靠應如何維護

作者:中科kaiyun混凝土攪拌車廠家 時間:2020-11-24

  驅動裝置的作用是驅動混凝土貯罐轉動,它由取力器、萬向軸、液壓泵、液壓馬達、操縱閥、液壓油箱及冷卻裝置組成。如果這部分因故障停止工作,混凝土貯罐將不能轉動,這會導致車內混凝土報廢,嚴重的甚至使整罐混凝土凝結在罐內,造成混凝土攪拌運輸車報廢。因此,驅動裝置是否可靠是使用中需要高度重視的問題。為保證驅動裝置完好可靠,應做好以下維護工作:
The driving device is used to drive the concrete storage tank to rotate. It is composed of power take-off, universal axis, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device. If this part stops working due to fault, the concrete tank will not be able to rotate, which will lead to the scrapping of the concrete in the vehicle, and even make the whole tank concrete coagulate in the tank, resulting in the scrapping of the concrete mixer truck. Therefore, whether the driving device is reliable or not is a problem that needs high attention in use. In order to ensure the integrity and reliability of the drive device, the following maintenance work should be done well:
1.萬向轉動部分是故障多發部位,應按時加注潤滑脂,並經常檢查磨損情況,及時修理更換。車隊應有備用的萬向軸總成,以保證一旦發生故障能在幾十分鍾內恢複工作。
The universal rotating part is a fault prone part, so grease should be added on time, and the wear condition should be checked frequently, and the repair and replacement should be carried out in time. The team should have spare cardan shaft assembly to ensure that it can resume work in dozens of minutes in case of failure.
2.保證液壓油清潔。混凝土攪拌運輸車工作環境惡劣,一定要防止汙水泥沙進入液壓係統。液壓油要按使用手冊要求定期更換。一旦檢查時發現液壓油中混入水或泥沙,就要立即停機清洗液壓係統、更換液壓油。
Keep the hydraulic oil clean. The working environment of concrete mixer truck is bad, so it is necessary to prevent dirty cement sand from entering the hydraulic system. The hydraulic oil should be replaced regularly according to the requirements of the manual. Once it is found that the hydraulic oil is mixed with water or sediment, it is necessary to stop the machine immediately to clean the hydraulic system and replace the hydraulic oil.
全自動混凝土攪拌車
3.保證液壓油冷卻裝置有效。要定時清理液壓油散熱器,避免散熱器被水泥堵塞,檢查散熱器電動風扇運轉是否正常,防止液壓油溫度超標。液壓部分隻要保證液壓油清潔,一般故障不多;但生產廠家不同,使用壽命則不一樣。
Ensure that the hydraulic oil cooling device is effective. The hydraulic oil radiator should be cleaned regularly to prevent the radiator from being blocked by cement, and check whether the electric fan of radiator operates normally to prevent the temperature of hydraulic oil exceeding the standard. As long as the hydraulic oil is clean, there are not many faults in the hydraulic part, but the service life varies with the manufacturer.
感謝您的閱讀,此文的文章來源:全自動混凝土攪拌車更多的內容和問題請點擊:http://www.skar-bnat.com/kaiyun會繼續努力的為您提供服務,感謝您的支持!
Thank you for reading. This article is from automatic concrete mixer. For more information and questions, please click: http://www.skar-bnat.com/ We will continue to work hard to provide services for you, thank you for your support!


截屏,微信識別二維碼